Virgin Galactic SpaceShipTwo Crash Caused By Lack Of Oversight 

Virgin Galactic SpaceShipTwo Crash Caused By Lack Of Oversight 

An official investigation into the deadly crash of a Virgin Galactic SpaceShipTwo over California last October finds that a co-pilot unlocked the ship’s braking system too early. The incident, according to the National Transportation and Safety Board’s report, could have been prevented with better safety procedures.

At 9:19 PDT on October 31st, 2014, a Virgin Galactic SpaceShipTwo — a prototype vehicle designed to ferry tourists to the edge of space and back — took off from the from the Mojave Air and Space Port onboard a carrier aircraft. The test flight marked the first use of a new hybrid type of rocket motor, along with a new, plastic-based fuel.

It was a short-lived attempt. Seconds after separating from its carrier aircraft and igniting its engine, the spacecraft, flown by two civilian pilots from Virgin Galactic partner Space Composites, broke into pieces and fell back to Earth.

Virgin Galactic SpaceShipTwo Crash Caused By Lack Of Oversight 

Virgin Galactic rocket separating from the carrier aircraft prior to exploding. Image via AP/ Ken Brown

Virgin Galactic SpaceShipTwo Crash Caused By Lack Of Oversight 

SpaceShipTwo’s explosion in October. Image via AP / Ken Brown.

Secondhand reports at the time indicated that there seemed to be some sort of explosion:

But according to the NTSB’s official investigation, the breakup was not due to an engine failure. Rather, it was caused by early deployment of the ship’s feathering system by co-pilot Michael Alsbury. CNET reports:

In a normal flight, the ship rockets up and out of the atmosphere and then, momentum exhausted, falls gently back to earth. The wings fold backwards at this point to stabilise the return journey. Those wings are supposed to be locked in place until the ship accelerates through a speed of Mach 1.4 (just over 1,000mph, or 1,700kmph). However, according to the NTSB report, co-pilot Michael Alsbury released those locks early, at just Mach 0.92. Four seconds later, the ship flew into pieces.

Alsbury tragically lost his life in the accident. Pilot Peter Siebold’s seat was thrown clear, allowing him to release his harness and deploy his parachute.

The crash was considered a major setback for the aspiring space tourism company, which has been promising to ferry civilians out of Earth’s atmosphere for over a decade. An earlier accident involving a SpaceShipTwo rocket system claimed the lives of three Scaled Composite employees in 2007.

The NTSB report found that the pilots were properly certified, qualified, and not experiencing fatigue or other medical issues at the time of the incident. However, it does seems that a lack of experience with the SpaceShipTwo’s systems, and the particular challenges of rocket-based flight might have contributed to the failure:

Another disturbing revelation: In 2013, the FAA issued Scaled Composites a safety waiver for SpaceShipTwo. The waiver, posted on the website parabolicarc.com this morning, essentially gave Virgin Galactic’s partner company licence to carry out crewed flight tests without conducting an analysis of “hazards resulting from human and software error.” The FAA apparently issued the waiver “because the SS2 operation will not jeopardize public health and safety or safety of property, national security or foreign policy interests of the United States, and is in the public interest.”

According to the waiver:

A hazard analysis serves to reduce risk to the public by limiting the possibility of a vehicle mishap. Although Scaled did not complete its hazard analysis as required by the regulations, the combination of its training program, incremental approach to flight testing, use of chase planes, and two-pilot model, as well as the limited duration of the permit and thus the waiver, the remoteness of its operating area and its use of a winged vehicle combine to allow the FAA to find that Scaled’s activities will not jeopardize public health and safety or safety of property.

Huh. In hindsight, there might have been a few, er, teensy lapses in judgement on the part of the FAA:

At the NTSB’s recommendation, Virgin Galactic and Scaled Composites have already implemented several additional safety features, including a mechanical lock that will prevent the SS2’s feathering system from premature deployment, and a change to the checklist and call-outs pilots must go through before unlocking that system.

It remains to be seen when Virgin Galactic will resume testing.

[CNET]

Top image: Debris from the crash sits in the Mohave Desert on Nov.3. Image via Getty / Sandy Huffaker


The Cheapest NBN 50 Plans

It’s the most popular NBN speed in Australia for a reason. Here are the cheapest plans available.

At Gizmodo, we independently select and write about stuff we love and think you'll like too. We have affiliate and advertising partnerships, which means we may collect a share of sales or other compensation from the links on this page. BTW – prices are accurate and items in stock at the time of posting.